The Sportster was a little late to the 21st Century, not getting much in the way of improvements (except better brakes, and sealed wheel bearings in 2000) until the 2004 model year, but then came the most changes since the introduction of the Evo in 1986.
1- SuperLow®
2- Iron 883™
3- 1200 Custom.
4- SuperLow® 1200T.
5- Forty-Eight®
6- Seventy-Two®
7- Roadster™
1- 1957 Harley XL Sportster Ironhead. …
2- 1967 Harley Sportster XLH. …
3- 1969 Harley Sportster XLH. …
4- 1971 Harley Sportster. …
5- 1978 Harley Sportster. …
6- 1980-1981 Harley Sportster. …
7- 7. 1983 Harley Sportster XLX61. …
8- 2005 Harley-Davidson Sportster.
The only difference between the 883 and 1200 Sportster is their emblems that indicate which model they are. The 883 and 1200 Sportster are actually built with the same exact parts and there is no way you can tell just by looking if a model is an 883 or a 1200 aside from the emblem.
It’s all in the VIN # located on the motorcycle’s frame. Where is the VIN # on a Harley-Davidson Sportster? Up close your VIN # should look like this. The letters below (4) (the 5th and 6th characters in your VIN number, beginning with the letter C) represent what model of Sportster you have.
Let’s not forget that in 1970, renowned racer Cal Rayborn rode the 90ci Harley-Davidson Sportster Streamliner to set a new land speed record of 265.492 mph on the Utah Bonneville salt flats, a record that remained unbroken until 1975.
What year did the Sportster change?
The Sportster was a little late to the 21st Century, not getting much in the way of improvements (except better brakes, and sealed wheel bearings in 2000) until the 2004 model year, but then came the most changes since the introduction of the Evo in 1986.
What are the different Sportster models?
It simply has larger bores; approximately 3.5 inches to the approximate 3 inch bore of the 883. Simply put, the 1200 Sportster engine has a bit more material and weighs slightly more than the 883 engine; the difference in weight is too small though to make a significant effect on performance.
What year Sportster is best?
Although they retain the same basic frame and engine layout, the new Sportsters have been almost totally revised, and are again motorcycles that can be taken seriously on their own merits. There are a number of significant changes-engine improvements, stiffer frames, new brakes, improved finish, etc.
What is the difference between the Sportster?
The only difference between the 883 and 1200 Sportster is their emblems that indicate which model they are. The 883 and 1200 Sportster are actually built with the same exact parts and there is no way you can tell just by looking if a model is an 883 or a 1200 aside from the emblem.
How do I know what kind of Sportster I have?
It’s all in the VIN # located on the motorcycle’s frame. Where is the VIN # on a Harley-Davidson Sportster? Up close your VIN # should look like this. The letters below (4) (the 5th and 6th characters in your VIN number, beginning with the letter C) represent what model of Sportster you have.
What does XL stand for Sportster?
They stand for 883 cubic centimeters and 1200 cc respectively which are in the Sportsters. An 883 can get new 1200 cc cylinder heads if desired.
What year is the fastest Sportster?
Let’s not forget that in 1970, renowned racer Cal Rayborn rode the 90ci Harley-Davidson Sportster Streamliner to set a new land speed record of 265.492 mph on the Utah Bonneville salt flats, a record that remained unbroken until 1975.
Are Sportster engines reliable?
All Sportsters still run the time-tested Evolution engine, which has shown to be one of the most reliable motors in HD history. Also, FYI, all Sportsters introduced from 2007 forward have electronic fuel injection, and all Sportsters introduced from 2004 forward have rubber-mounted engines that reduce vibration.
How many miles will a Sportster engine last?
How Long Will A Harley Sportster Last? With good care and maintenance, Harleys can travel over 75,000 miles with just over 100,000 km on their odometers or a couple of weeks at a time.
Which is better Sportster 883 or 1200?
Simply put, the 1200 Sportster engine has a bit more material and weighs slightly more than the 883 engine; the difference in weight is too small though to make a significant effect on performance. If you have an 883 Sportster and you want to turn it into a 1200 Sportster, some shops are able to do it for a price.
Which is faster 883 or 1200 Sportster?
They stand for 883 cubic centimeters and 1200 cc respectively which are in the Sportsters. An 883 can get new 1200 cc cylinder heads if desired.
How can you tell what model Sportster you have?
1970 thru 1980 Sportsters First two digits of the Harley VIN are the model code. Example: 4A 12345H1 is a XLCH 1981 to 1985 Sportsters 5th and 6th digits are the model code. Example: 1HD1 CD HY15B123456 is a XR1000 1986 to 1996 Sportsters 5th, 6th and 7th digits are the model code.
How do you tell if a Sportster is an 883 or 1200?
The only difference between the 883 and 1200 Sportster is their emblems that indicate which model they are. The 883 and 1200 Sportster are actually built with the same exact parts and there is no way you can tell just by looking if a model is an 883 or a 1200 aside from the emblem.
What’s the difference between an XL and Xlh Sportster?
The greatest difference is that an XLH is always going to have an electric starter, where the XLCH may not. CH had the 2.2 and the XLH had the 4 gal tank with a side mount oil tank to allow for the larger battery needed for the elecrric start on the XLH. There were no engine differences between the two in 1973.
What is Sportster XR?
What is a Harley-Davidson SPORTSTER XR1200? The Harley-Davidson® Sportster XR motorcycle has retro Harley racing style, fully adjustable Showa motorcycle suspension, and dual disc motorcycle brakes that have high performance and a sleek design.
Which year Sportster is best?
And while the 2004-2006 models are more comfortable, the 2003 and earlier versions are significantly lighter. Also, their transmissions are easier to service. For these reasons, r/Sportster sub-Reddit users recommend 2000-2003 models, as well as the 2007 and later ones.
More Answers On What Year Sportster Seats Interchange
sportster years parts that are interchangeable [Archive] – The …
What year works. Most 2005 seats will not fit on 2007-2009 Sportsters, because they don’t have room for the ECM under the seat (take your seat off and it will be obvious). As I understand, nearly any slip-on should work from 2004-2013. Folkie 28th September 2014, 23:43 sportster years parts that are interchangeable
Sportster seat fitment – part 52849-04A – Harley Davidson Forums
I found a possible seat for my Sportster – it is HD part 52849-04A. According to HD website this part number fits 2004 & up. According to the seller this part fits 2004-2006. Does anyone know if this part was changed? Does anyone know if Sportsters had a change in 2007 that would affect seat?
Harley-Davidson Sportster History: 60 Years of Sportster Models …
In 1993, the chain drive on Sportsters was replaced with a belt drive, and the following year the electrical systems on the Sportster line were upgraded. The XL 1200C Custom model Sportster arrived on the scene in 1996. All-New Frame Including Rubber-Mounted Engine for Decreased Vibration – 2004
Sportster History – Classic Motorcycle Build
1973 Sportster In 1973, the Sportster frame was modified. The steel castings were eliminated, and replaced with steel straps which covered the two frame tubes having the open holes. These two holes previously held the supports for the original solo seat. Generator Charging Problems
Harley-Davidson Sportster History 1970-2013 – Haynes Manuals
The current Haynes Manual for the Harley-Davidson Sportster covers recently produced models from 2013, but goes back all the way to 1970! For 43 years, there is enough in common that we did not feel the need to create a whole new book. However, in 2014 Harley gave the bike a substantial update, changing how it was wired, how the fuel injection …
Sportster History (with VINs & Specifications) – Sportsterpedia
First year for XR-750 as a specialty model with a 45ci OHV racing V-twin. In consideration of new AMA rules for Class C racing, a new Sportster®-based motorcycle, the XR-750 racer is introduced. 107) The XR750, which in basic design was a destroked iron cylinder Sportster engine. The engine was housed in a proven KR-style swingarm chassis with …
Harley-Davidson Sportster – Wikipedia
The Harley-Davidson Sportster is a line of motorcycles produced continuously since 1957 by Harley-Davidson.Sportster models are designated in Harley-Davidson’s product code by beginning with “XL”. In 1952, the predecessors to the Sportster, the Model K Sport and Sport Solo motorcycles, were introduced. These models K, KK, KH, and KHK of 1952 to 1956 had a sidevalve (’flat head’) engine …
Sportster Seat Help….Will it Fit? – ChopCult
Does anyone know if a stock 2-up seat from a 1987 Sportster will fit on a stock 1996 Sportster XL1200? I see that usually Sportster seats fit 82-95 and then 96-03, but then sometimes I see that some seats fit 82-03 so whats the deal? Also, I don’t mind if there is a gap between tank and seat, all I want to know is will the older seat slip in and line up with the stock mounting bracket in front …
Seat Interchangeability – V-Twin Forum
AustinFXDWG said: Dyna seats interchange with other dynas except for the Wide glide which is unique. They don’t fit softails or touring bikes. Softail seats fit only softails, and won’t fit dynas or Touring bikes. I think the Deuce is like the WG in that it is unique because of the rear frame/tire width, but not sure.
Replacing your Harley seat: Tips and tricks – RevZilla
Another Sporty-specific fitment issue we run into is on 2007-2009 XL models, because those bikes have a very limited selection of seats meant to fit them. During these years, the Motor Company located the ECU on top of the frame, and the OEM saddles had a recess in the seat pan for them. That’s the only difference.
2007 Sportster – Sportsterpedia
Model Year Changes. Summary of changes for MY 2007: 14) Electronic Sequential Port Fuel Injection with O2 sensors. ALL 2007 models receive the “W” cams, reportedly giving the 883’s 15% more torque. New Speedometer with clock and dual trip meters (and UK dual faced) LED Indicators for high beam, oil light, turn signal indicators, and neutral …
What’s years and seats interchange? – S-10 Forum
1,760 Posts. #2 · Nov 29, 2011. Only show this user. Search. haha just kidding. all buckets from 82-04 will swap with no mods.. and all bench seats from 82-04 will swap. there all interchangeable.. if a blzer had heated seats.. you would have to wire up for that stuf, but as far as bolt in.. they will interchange based on type of seats.. you …
Harley Davidson Sportster Seats – Saddlemen
Year Make. Model. Sub-Model … Sportster seats, 48 seats, Iron 883 seats, forty-eight seats sportster gel seat. Sort By: Show: Product Compare (0) 1958-1978 XL Sportster Explorer™ Ultimate Comfort Seat . $382.00 . 1958 Harley-Davidson Sportster XL883 Sportsters (3.3G FUEL TANK)1958 Harley-Davidson Sportster XL900.. …
The Top 10 Harley Davidson Sportster Models of All-Time
7. 1983 Harley Sportster XLX61 Clearly one of the greatest marketing moves in Harley Davidson’s history, the XLX61 was introduced in 1983 with no frills. The bare boned machine featured nothing more than a single gauge, peanut gas tank, and a solo seat. It came in black version only and was designed to sell at $3,995.
Harley Davidson Sportster Seats – Solo & Passenger Motorcycle Seats for …
When it comes to Harley Sportster seats, Viking Bags offers specific ones intended for these Harley Davidson Sportster series: Seats for Sportster 883 Low XL883L. Seats for Sportster 883 Iron XL883N. Seats for Sportster 1200 Low XL1200L. Seats for Sportster 1200 Custom XL1200C. Seats for Sportster 1200 Nightster XL1200N.
What’s year seats are interchangeable? – Matthews Volvo Site
Entire seats only 99/00… 98’s have a mechanically actuated SIPSbag whereas the 99/00 has SIPSbags controlled by the SRS computer. Except SIPS system differences,like cmblackburn mentioned,they are all physically interchangeable between 850 and s,v,xc70 up to p2 models. Ideally,you would need a seats from ’99 and ’00 s,v,xc70 because of SIPS …
Frame Mount EVO Sportster Talk (1986-2003 models) Auto Parts Interchange | Gates Corporation – Use Gates Part Locator to find automotive replacement parts and products for your vehicle. Get started now! Boom!
Seats for Harley-Davidson Sportster for sale | eBay
Two Up 2-Up Driver Passenger Seat For Harley Sportster XL 883 XL 1200 2004-2018 (Fits: More than one vehicle) $143.95. Free shipping. or Best Offer. 58 watching.
Harley-Davidson Sportster Seats – Dennis Kirk
Shop for Sportster seats, Sportster seat or a Harley Sportster seat. Best selection at low prices. Get your parts fast with same day shipping. We Ship Today! www.denniskirk.com. 800-969-7501. Contact us: 800-969-7501; As low as 0% APR for 12 months with; Dennis Kirk Inc. Enter keyword or part # …
Sportster 18 inch rear wheel swap *help* – Jockey Journal
2,139 Posts. #4 · Mar 13, 2013. The answer to your question depends, in part, on what year your Sportster is. On the early Sportster, which came from the factory with an 18″ rear wheel, the fender was just barely wide enough to get a 5.00×16 tire on a 16 x 3 rim up under the fender. (and if the bike had ever been down, and the fender struts …
A brief history of the Harley-Davidson Evolution Engine
Last year of EVO’s in Baggers – 1998; Last year of EVO’s in Softails – 1999; Last year of EVO’s in FXR’s – 2000; Until 2000, when the last Harley-Davidson Evolution engine was produced Some more photos of Evo Big Twins and Evo Sportsters. Reece Zylstra’s Evo chopper from Fuel Cleveland. Longhair’s stock Evo Sportster. Tracker Style Evo Sportster.
Mustang Seat Interchangability….What years are the same?
May 19, 2008. #2. Yes and no. If you are interested in just the power track, you may have a problem. The bolt pattern on the floor is the same from 79-04 so any seat tracks can be changed amongst those years easily. The problem arises with the 99-04 seat tracks where they bolt to the seats themselves. Ford in their infinite wisdom changed the …
Harley-Davidson Sportster & Bobber Seats | Killer Custom
Seat Foam For 2008-2017 Softail Twin Cam “Short Oval” And “Fat Racer” Fenders Only
Harley Davidson Sportster Model Specifications and Differences
Sportster 1200 Custom. Next up is the 1200 Custom, which is the epitome of Harley Davidson styling and a favorite of Sportster fans. It comes standard with a two up seat mid-controls, and low handlebar. Most importantly, it has that somewhat famous fat front tire. This bike comes in six different colors and of course has the larger 1200cc engine.
Amazon.com: Sportster Seats
OUMURS Solo Seat for Harley Sportster Solo Seat Front Driver Seat for Iron Sportster 883 All XL Models 1983-2003, Motorcycle Springer Seat Cushion Pad for Sportster 1200 Custom Sport XLH 883 Deluxe. 5.0 out of 5 stars 6. $89.95 $ 89. 95. Get it Thu, May 5 – Mon, May 9. FREE Shipping. Only 9 left in stock – order soon. Motorcycle Black Synthetic Leather Stitched Two 2-up Front Rear Driver …
Harley Davidson Sportster: How to Swap Front Brake Line and Add Riser …
Step 4 – Drain the brake fluid. Attach a length of 5/16″ hose to the front brake bleeding screw and place the end of the hose into a container. This container must be large enough to hold all the fluid in the master cylinder. Loosen the bleed screw one full turn and wait several minutes as gravity moves the fluid through the hose and into the …
Harley Sportster Seats for 1982 – 2003 Models by LePera
SPORTSTER :: ’82-’03. The LT Series seats are designed for stock 1200 or ’00-’03 tanks; it has an extended nose to go up on the tank. The Non-LT Series seats will have a gap between the seat and the tank with pre-’00 peanut tanks, with stock 1200 or ’00-’03 the seat will go up to the tank.
Harley-Davidson Sportster Seats – ALEX LEATHER CRAFT
Stylish motorcycle seats from Alex Leather Craft, made specially for your Harley Davidson from 2004 to 2020. Handmade in Germany.
Harley-Davidson Sportster Corbin Motorcycle Seats
XL 883R, XLH, XL 883C, XL 1200C, XL 1200S, XLH 883, XLH 883 Hugger. NOTE: These seats are designed for the `96-`03 chassis with the large fuel tank installed (1200 model). For `96 models with the 883 style tank, please order from our `82-`95 model section. These saddles also fit the `01-`03 Sportsters with the 3.3 gallon tank. Gunfighter. Gambler.
Year/Model Interchange List — All Makes — Cars and Trucks 13-Apr-12 Suggestions for using the YEAR/MODEL I TERCHA GE LIST (Clones/Sisters List): This list is created for researching primarily frontal impact tests. The first year produced may contain a reference to which vehicle the subject vehicle was based on, if applicable, or Whether the subject vehicle was a restyle of an existing …
Resource
http://xlforum.net/forums/showthread.php?t=1823149
https://www.harley-davidsonforums.com/threads/sportster-seat-fitment-part-52849-04a.13059/
https://www.lowbrowcustoms.com/blogs/events-features/history-harley-davidson-sportster-blowing-away-big-twins-since-1957
http://www.classic-motorcycle-build.com/sportster-history.html
https://haynes.com/en-us/tips-tutorials/harley-davidson-sportster-history-1970-2013
http://sportsterpedia.com/doku.php/sportster_history:99xx-01
https://en.wikipedia.org/wiki/Harley-Davidson_Sportster
http://www.chopcult.com/forum/showthread.php?t=19252
https://www.v-twinforum.com/threads/seat-interchangeability.57204/
https://www.revzilla.com/common-tread/replacing-your-harley-seat-tips-and-tricks
http://sportsterpedia.com/doku.php/sportster_history:2007_sportster
https://www.s10forum.com/threads/whats-years-and-seats-interchange.483316/
https://saddlemen.com/sportster
https://moneyinc.com/top-harley-davidson-sportster-models/
https://www.vikingbags.com/harley-davidson-sportster-motorcycle-seats
https://www.matthewsvolvosite.com/forums/viewtopic.php?t=81085
https://www.actualusa.com/harley/harley-parts-interchange-guide.pdf
https://www.ebay.com/b/Seats-for-Harley-Davidson-Sportster/183727/bn_7066429715?mkevt=1&mkcid=1&mkrid=711-53200-19255-0&campid=5336728181&customid=&toolid=10001
https://www.denniskirk.com/harley-davidson/sportster/seats
https://www.jockeyjournal.com/threads/sportster-18-inch-rear-wheel-swap-help.103386/
https://www.lowbrowcustoms.com/blogs/events-features/a-brief-history-of-the-harley-davidson-evolution-engine
https://www.stangnet.com/mustang-forums/threads/mustang-seat-interchangability-what-years-are-the-same.750460/
https://www.killercustom.com/collections/seats
https://www.hdforums.com/how-tos/a/harley-davidson-sportster-model-specifications-and-differences-413507
https://www.amazon.com/Sportster-Seats/s?k=Sportster+Seats
https://www.hdforums.com/how-tos/a/harley-davidson-sportster-how-to-swap-front-brake-line-and-add-riser-extension-412715
http://www.lepera.com/v4_Sport_82_result.php
https://leathercraft24.com/en/motorradsitze/seat-for-hd/hd-2004-2020/hd-sportster-seats/
http://www.corbin.com/harley/xl/
https://www.edccorp.com/library/TechRefPdfs/EDC-1057.pdf